Volvo XC60 XC70 XC90 V70 Power Transfer Unit / Transfer Box / Front Differential  Reconditioned - Same Day Service - 2 year warranty

If your Volvo XC60 XC70 XC90 V70 power transfer unit / transfer box / front differential is damaged we can supply you with a Reconditioned Unit.

WHAT HAS CAUSED MY POWER TRANSFER UNIT / TRANSFER BOX / FRONT  DIFFERENTIAL TO BE DAMAGED?

In most cases damage to your power transfer unit / transfer box / front differential is caused by mismatched tyres.

It is very important on a Volvo XC60 XC70 XC90 V70 Drivetrain for the tyre sizes to be matched between the front and rear axles. The difference in tyre diameter, and thus the rolling radius of the wheel, causes slippage in the drivetrain, which is what they are designed to do off road if the wheels start to slip and this transfers drive to the other wheels, but as this is happening while driving in a straight line on a road it causes extra load to the entire transmission line, eventually resulting in Rear Differential and / or Power Transfer Unit failure. This constant strain can also affect the Haldex unit and gearbox if the situation continues.

Mismatched tyres can occur from fitting different size profile tyres to the front of the car compared to the rear; putting new tyres on one end of the car but leaving the old worn tyres on the other or low tyre pressures and vehicles that have done a lot of towing (rolling radius of tyre is less due to the weight of the trailer compressing the tyres). A difference of just 5mm in diameter dramatically increases the rotational differences between the front and rear axles, so it is imperative that the tyres are always matched. Always change all 4 tyres at the same time, rather than trying to save a few pounds by changing the fronts and getting a few more miles out of the rears. The variations between makes of tyres with the same profile can be even more than this, so tyre makes should also be matched.

HOW CAN I TELL IF MY POWER TRANSFER UNIT / TRANSFER BOX / FRONT DIFFERENTIAL NEEDS REPLACING?

A problem with the Volvo XC60 XC70 XC90 V70 power transfer unit / transfer box / front differential can show itself in two different ways. 
1. You may hear a whining noise from the front of your Volvo XC60 XC70 XC90 V70, a little like road noise, which tends to get louder when you place the Volvo XC60 XC70 XC90 V70 under load, such as when you are accelerating - this is the most common symptom.
2. You lose the four wheel drive, so when you need grip the front wheels start spinning and you just skid around, rather than get out of that muddy field - this could also occur if you have a problem with your rear differential or Haldex.

Warning: If your power transfer unit failed because of mismatched tyres then you will need to replace your tyres, otherwise you will damage your replacement power transfer unitl all over again - and your warranty will not cover you because it will have been damaged by an external component!

WHAT IS A RECONDITIONED POWER TRANSFER UNIT / TRANSFER BOX / FRONT DIFFERENTIAL?

Our reconditioned power transfer unit / transfer box / front differential have been fully dismantled, cleaned, inspected and fitted with all new bearings, and seals. 

PLEASE NOTE: If the there is damage to other parts of the unit, other than the bearings and the seals, your power transfer unit / transfer box / front differential will not be suitable for reconditioning. In this instance we should be able to supply a replacement core unit to recondition, however this will incur a £300 surcharge.

Everything in the unit is inspected and tested to ensure it is fully functional and worthy of our unlimited mileage 24 month warranty.

SHOULD I CHANGE MY TYRES?

The most likely cause of power transfer unit / transfer box / front differential damage is a mismatch in tyres. If you do not address this issue you will experience the same damage all over again. 

CAN YOU FIT MY POWER TRANSFER UNIT / TRANSFER BOX / FRONT DIFFERENTIAL FOR ME?

Certainly we can fit your power transfer unit / transfer box / front differential for you, and we can remove, recondition and refit it all in the same day!

• Supply a reconditioned power transfer unit / transfer box / front differential;
• Fit your reconditioned power transfer unit / transfer box / front differential;
• Fill your power transfer unit / transfer box / front differential with the correct oil;
• Fill your gearbox with the correct oil - so you get the benefit of a gearbox oil change at the same time;
• Check your drivetrain for any other issues which may affect your newly fitted power transfer unit / transfer box / front differential.
• and have you back on the road again in no time!

Please contact us with your vehicle registration and chassis number so we can provide you with a quotation.

If your car does not drive and you need to get it to us to fit your reconditioned power transfer unit / transfer box / front differential why not try:
1. Phoning your breakdown recovery service, if you have one. These will sometimes transport your car for free, or at a reduced rate.
2. Sending us a message and we will arrange to transport your car to us for a cost of £2.00 per mile (calculated one way only to IP26 4RH). We can collect from anywhere in Europe (ferry crossings will be charged additionally where applicable).

The cost of supply only for the reconditioned power transfer unit / transfer box / front differential, excluding shipping or fitting, is £545 incl. VAT.

DO YOU HAVE THE POWER TRANSFER UNITS / TRANSFER BOXES / FRONT DIFFERENTIALS IN STOCK?

We generally recondition your existing power transfer unit / transfer box / front differential - this ensures you have the correct unit for your vehicle. We will arrange the courier to collect your unit. UK shipping is 1 day, we aim to recondition your unit in one day and return it back to you on next day courier - so our aim is to have your unit reconditioned and back to you within 3 working days. EU shipping is generally 2 - 5 days each way. For the rest of the World please contact us with your location for a shipping schedule.

DO I NEED TO RETURN MY DAMAGED POWER TRANSFER UNIT / TRANSFER BOX / FRONT DIFFERENTIAL TO YOU?

Generally we will recondition your existing unit (provided it is in a reconditionable state and does not have damage to the shafts - if damage exists and the unit is not reconditionable we should be able to supply a core unit at a surcharge of £300).

The shipping costs include the cost of shipping your damaged power transfer unit / transfer box / front differential to us, and returning it to you once it has been reconditioned. We will organise the courier, all you have to do is tell us when it will be ready to be collected.

DO YOU SHIP WORLDWIDE?

Yes we do. The following shipping prices include shipping your damaged power transfer unit / transfer box / front differential from you to our workshops, and returning it, reconditioned, from our workshops to you:

• UK Shipping £35
• European Shipping £95 (estimate - see below*)
• For the rest of the World the shipping costs include the shipping cost, the non-return surcharge (as it is not economically feasible to ship the old units back to us from outside of Europe) and the deduction of the VAT on the unit. The shipping prices are:
• Australia / USA / Canada £165 (estimate - see below*)
• Rest of The World Shipping £215 (estimate - see below*)

*Please note, some remote areas may be subject to a shipping surcharge. If your country / area may be considered remote please contact us with your address for a shipping quotation.

WHAT IF SOMETHING GOES WRONG?

We don't like things going wrong, and you certainly wouldn't! Quality is important to us, but in the event that something does go wrong you have our

Our warranty covers you for a replacement power transfer unit / transfer box / front differential in the event of any failure of a component due to faulty parts or workmanship.

IMPORTANT: Because it is common that damage to the power transfer unit / transfer box / front differential is caused by mismatched tyres, your warranty will only be valid if your tyres are matched.

All of our units / work come with a 24 month return to base warranty against defective parts or poor workmanship. If you have a problem with any of our products or work please do not hesitate to contact us, we want happy customers and will do our best to sort things out.

If your item arrives damaged, defective or not as described, please contact us within 14 days of receiving the item and we will issue a full refund within 5 working days of receiving the return, provided it is in an unused condition and is as was received.

If you change your mind or no longer require the item, provided it is not a reconditioned to order item we accept returns within 14 days of receipt of the item. In these circumstances the item must be in unused condition and exactly as received. A refund of the item, excluding shipping, will be made within 5 working days of receiving the return.

This said, no matter what the issue you may have with any of our items please just contact us, we are here to help!

We are FreelanderSpecialist. As the name suggests, we specialise in Land Rover Freelander's, both the Freelander 1 and the Freelander 2.

We specialise in reconditioning the drivetrain units and the engines for all Freelanders. We also carry out repairs and servicing.

Since the Freelander engines and drivetrains are used in some other makes of vehicles (for example the Rover, MG, Lotus, Volvo and Range Rover Evoque) we also recondition units for these vehicles.

We have been working on (almost) nothing but Freelander's for so many years now we like to think we are pretty good at it! So if you have any issue with your Freelander that you would like discuss please do not hesitate to contact us.

Here are some things people have been saying about us:

"Thanks Sue and Norbert for rescuing me. My Freelander with it's 'new' engine drives so well. I feel like I have a brand new car. I promise to look after it. Many thanks for your most excellent service, in both picking up the car and repairing it. I will certainly come to you again and recommend you to friends.
Thanks again."
"Thank you for saving our lives.   All went as planned and our gearbox replacement is installed and the car is once more on the road.   Thanks to our super cooperation on this problem the parts arrived in Greece within a week solving an outsize headache.   It was a pleasure doing business with you."
"Hello Sue and Norbert
Tried the rest and you are obviously the best, when it comes to Freelander knowledge. Thank you for meeting us at the station, saw my cleaned and shiny car and your smile.We enjoyed meeting you, shame that Norbert was out on a call? helping some unfortunate motorist.
A genuine thank you."
"had a modified head gasket fitted over 3 months ago and the car has run really well ever since, sue and norbert are helpful and full of knowledge, i will be using them in the future and can't praise them enough"
"After many concerns regarding problems with my car and bad advice in Portugal we shipped the car to Sue and Norbert. Their service was thorough and the car was brought back to fine running order.  We have no hesitation in recommending them to any Freelander owners with problems
Thank you very much for all the good work and the patience of Sue with all our email questions."
"Sue it was so great to meet you and Nobert on Saturday and the car is running great!
I thought I would drop you this email ... to say a big thank you so you can add to your already impressive testimonials page - your communication was first rate, the job was carried out quickly and cheaply (compared to ANYWHERE else!) yet professionally and all whilst we waited and were treated to a cup of tea and a friendly chat.  We'll be back, but hopefully not too soon!! ..."
"Hi Sue & Norbert may i take this oppertunity to thank you for the work done on my rover 75 after 3 months with garages and a lot of money i found you and i am glad i did you have both been very helpfull and Norbert has solved the problem on my car in 1 week and at a good price i will recomend you at all times and thank you both for you time and help with my car"
"Hi Sue, Nobert, Ooh! and large dogs,
Sorry for the delay getting back to you both. I would like to thank you for the very proffessional service and Reconditioned Engine in my Rover Sterling. It is running great!!"
"You worked on my Rover 25 ... It's absolutely fantastic. Thanks ever so much. I'm really, really, really pleased and I can't thank you enough."
"Well, what can I say! After a year of bad advice from various people we finally had the car fixed by Nobert and Sue. Replacement of IRD, VCU, Rear Diff and other work all because we were given incorrect advice initially for what turned out to be a wheel bearing which led us to replace all the above parts last year (recon parts), however it turns out that we were supplied some 'iffy' parts which actually caused a problem that was never there before! Having them all replaced again by Nobert with his expert knowledge is such a relief. Both Sue and Nobert are very ameniable, honest and hard working people. The car is going fantastically (it will be a while before I stop expecting it to 'clunk' mind you!) but I can really enjoy the car again. Thank you both very much and p.s. I'm glad I was able to hopefully solve a mystery for you (water in the boot)! Take care both of you."
"Got a Freelander? Need help?? Can you get to Norfolk?.. there is a little jewel of a Company there called FreelanderSpecialist, which you must look up.
I purchased my first Freelander recently, thinking I had got myself a bargain. Not so... a replacement clutch, major overhaul of the front suspension. New discs and pads. New viscous coupling and thorough service...the car is restored to its former glory.
The work has been carried out to exceptional standards and I am sure at a fraction of the cost I would have incurred at a main dealership.
Above all this though, I have to tell you about Sue and Norbert..they are the heartbeat of the business. Whilst many companies may talk up the importance of customer service, these great people really "walk that talk". Nothing was too much trouble for them and their passion for Freelanders is quite infectious.
A huge thank you to both of you!!
Once again I recommend you go that extra mile to visit them. I assure you they will go an extra 10miles for you and your Freelander."
"This company is almost 300 mile from my home. I took my Freelander to them in November 2011 for various works having tried a number of local companies who clearly didn't know the workings of a Freelander.
The service and quality of work from this company was well worth the trip and i will be using them again for future works including servicing and MOT. If you want the job done properly the use this company."
"Many thanks Sue and Norbert,
Having been misinformed by two separate and local mechanics that "without a shadow of a doubt" my problem was a head gasket issue, we stumbled across the Freelander website and, reading sue's knowledgeable advice and the fantastic testimonial given, decided to give them a try.
Sue and Norbert were the only ones to correctly diagnose a smaller-and therefore cheaper job than previously advised. The job was completed in a timely and professional manner, with Sue always on hand to answer any queries and give updates as required.
'Without a shadow of a doubt' we know where to come for all our Freelander requirements now! Sue and Norbert are both professional, knowledge, friendly and honest; a real rarity these days, especially in the motor mechanical field.
We are so pleased to have discovered you via the website. I only hope this testimonial helps you to gain further extremely satisfied customers such as ourselves."
"I had been having a problem with my rattling Freelander for approx. 24 months.  It had been in two different local garages and both had failed to fix the problem despite me spending hundreds of pounds.
Luckily i found Sue and Norbert on the internet and after exchanging several emails i was confident to drive the 3+ hours to Norfolk for them to look at my car.  As a family we were also prepared to stay 2 nights in a local B & B to give them enough time to thoroughly check the car over.
If only i had discovered you earlier i would have saved myself a lot of heartache and money.
Thanks for all your help and the car now drives fantastic, just like it was when i bought it.
Please don't have any doubts about traveling any distance to Freelander Specialist for them to fix your car because based on my experience......they will fix it.
Nice one Sue and Norbert."
"Anyone who buys a Freelander should immediately take it to Freelander Specialist. Nobert is the master chef of the Freelander, and Sue is front of house. They unlike all the other so called " Specialists " know what they are doing, they do the job well and thoroughly and do not rip you off !.We could have saved a lot of anguish and cash if we had taken our Freelander to them for a check over when we first purchased it. Nobert has fitted a recon IRD box and front drive shaft and the vehicle seems smooth and with no tummy churning knocks or clicks. All Sue's comments on drive train issues are correct and Nobert is so thorough in his work it inspires total confidence, they know what they are doing.Thanks to you both a pleasure to meet you, keep up the good work !."
"Dear Sue and of course Norbert,
Many thanks for the repair of my V6 2.5l Freelander. My wife's pride and Joy. After many garages including Landrover dealerships told me to patch it up and sell ASAP, I was over the moon to find someone who would not only recondition the engine but give it a decent warranty. The courteous service by yourselves and the collection driver ( Steve I think ) showed the pride and passion you all have and was a breath of fresh air. I've only done a100 miles to bed the engine in so far but it is certainly a better car. I can't wait for my wife to see it again tomorrow when I drive back home.
Many many thanks for the service and will certainly use you again when the time comes."
"After countless repeat failures you guys have brought my Freelander back to life!! ( she purred on the very first kick) Kudos to you Sue & Norbert Thanks so much"
"recon'd the diff and sorted out other issues with haldex unit, lent me a courtesy car to get on with my day all for the set price of £750. Was ready that day, done and dusted no bother. I had a quote from another place for 3000 quid for new diff etc.!. Thank you Sue and Norbert, I would highly recommend you to everybody with land rover problems"
"Sue and Norbert,
Thank you so much for sorting out my dream car, which seemed to be turning into a nightmare, until we found you!!
Your customer service is second to none, not only in sorting out the car but also the little things that you did for us and 'Beyoncé'(I name all my cars!) and that's not even mentioning the £1,000 that you saved us by diagnosing the problem correctly.
It's such a pleasure to meet such a trustworthy and honest garage service, which can be such a minefield.
I would completely recommend you guys to anyone and a huge thank you for your time, service and sincerity with us."
"EXCELLENT SERVICE + GREAT COMMS + VERY FAST AND EFFICIENT JOB + HONEST A+
Dear Sue and Nobert
Just wanted to say what fantastic service we were offered when we travelled 220 miles from Bristol to get our differ/bearings reconditioned on our freelander 2 sd4 2010 - we had several quotes in and around Bristol who were charging over £2000 for the work - we were charged £750 by sue and nobert who we found by chance by browsing the internet and had no hesitation to travel up the 220 miles after reading there excellent reviews.
Myself my wife and my 3 children travelled up early morning we were welcomed by lovely sue who was so kind and friendly she offered us all a drink and let us chill out in her living room where she gave us so much advice. we were offered a loan car whilst our car had work done to it which was going to take most of the day we really appreciate nobert carrying out the work in one day as other companies were telling us it was going to take at least 5 days.
we had a lovely time with the kids at a park nearby when we came back sue offered us another drink and told us to have a rest and watch tv in her living room it was really nice of her as the kids were worn out and slept until the car was ready.
Please if you want the best service and you live a distance from Norfolk I will highly recommend sue/nobert - they really are the most kind and friendly people you will ever meet, I personally have made two very good friends and I will not hesitate to visit them again if I have anymore problems with my freelander 2 sd4 2010.
Thank you so much sue and nobert."
"This must be the best place in the UK to have work carried out on a Freelander.
Having travelled 402 miles from Edinburgh to have transmission and clutch work carried out by FreelanderSpecialist I was delighted by the service I received. My vehicle was ready for collection as promised and I'm delighted with the work done.
This is DEFINITELY the place to go for Freelander work."
"Big thank you to Sue+Norbert. Well worth the 200+ mile round trip to have the front prop shaft replaced on my Mk 1 Freelander at very reasonable cost They also investigated a couple of other issues for us at no extra charge. Sue gave us lots of valuable freelander advice over a coffee in her sitting room during our short wait for the work to be completed. All in all my best motor trade experience ever, felt more like a day out with friends!. Will certainly be back."
"In these days of electronic diagnosis, often undertaken by fitters, it's a welcome surprise to come across experts who thoroughly understand the workings and most importantly weaknesses of the vehicles in which they specialise. Norbert and Sue of Freelander Specialists are such experts.
Underscored by their prodigious work ethic, I find it extremely comforting to be able to drive away from their premises knowing that whatever has been done to either of my cars (Freelanders 1 and2) has been properly understood and dealt with.
Despite the two hour drive to get there, I'll no longer cast about locally trying to find an establishment I can trust - it's straight up to Norfolk, because I know what I'm getting. Also, if it's a job to be completed in a day, nearby historic Ely is a very pleasant place in which to while away the time.
"We fix it" - yes, they do!"
"Fantastic service I bought a vcu from them and they sent it straight to my garage for fitting. The garage could not get the old prop apart so I took it back to freelanderspecialist.com they fitted it for me. I also suspected the ird to be worn so they checked for me and it turned out to be a drive shaft which they fitted. Car is running great now thanks for all your advice and help.
"Just wanted to say thank you particularly to Norbert for a job very well done the car is running like a dream and no noise.It really was a pleasure to meet you both and I will be happy to recommend your services to anyone."
"Sue,
Was really good to see you both last week. I have to say that from the moment I left your premises I could notice a distinct improvement in performance from my car. Pull away from standing start was much swifter as was acceleration on kick down. However on top of that I've noticed a considerable improvement in MPG. After driving around Essex countryside for a couple of hours I was averaging 36.1mpg. I also had a run out to Heathrow and back and with the same sort of MPG. I think that definitely shows the value of having a proper service carried out!"
"Hi Sue,
I trust that you’re keeping busy and that all is well with you and Norbert.
I wanted to write and thank you both for the great job you did in helping me begin the renovation of my 18-year-old three-door 1.8K Freelander...
The Freelander has run like a dream ever since. It feels like factory new and my subsequent journey from Brandon/Cambridge over to Manchester and then onward to SE London was entirely uneventful. ...
Once again, I would like to say that I really appreciate your specialist expertise in association with what is a currently a relatively underrated Land Rover marquee and a true milestone motor vehicle. One that is certain to be a future classic.
Keep up the great work and all the best."  
"Wow! Thank you very much Sue and Nobert, this is like driving a new car: smoother, more economical (I think), and it's not cutting out. All the best to you both"
"Dear Sue and Norbert
 Thanks so much for fixing the haldex and rear diff issues on my F2.  Your detailed diagnosis, patient explanation, hospitality and kindness - and tremendous value - were very much appreciated. I have no hesitation in recommending you to anyone with Freelander problems.  Thanks again! "
"Took my freelander all the way from Northern Ireland to Sue and Nobert to fix 4WD and it was returned to me driving like a dream back to 4WD with all its other problems sorted. Amazing knowledge and expertise from you guys. Brilliant service and superb support. To all freelander owners, contact Sue and Nobert, I can't recommend these wonderful guys enough! Can they fix it? - Yes, they can!! Thanks so much.. really enjoying my freelander again... Sue and Nobert.. made of the right stuff! Above and Beyond!"
"Hi Sue & Nobert,
Absolute Geniuses, wow I,m so glad I brought my freelander to yourselves, you love my car as much as I love it so nice to see. Please tell the lads Thank you aswell. will not take it anywhere else 10/10. THE BEST.
Many Thanks"

We are located in Norfolk, midway between Cambridge and Norwich. Our address is:

FreelanderSpecialist
Glebewood Lodge
Brandon Road
Methwold
Norfolk
IP26 4RH
United Kingdom

We can be contacted through the eBay messaging system, or by telephone on the number in the Business Seller Information section.

If you have a question, please do not hesitate to contact us, we are here to help.