FORD TRANSIT COURIER Exhaust Manifold Mk1 1.5 Diesel 14-20 ONLY DONE 9816MILES

Check Out Our Feedback

Product Description

FORD TRANSIT COURIER Exhaust Manifold Mk1 1.5 Diesel 14-20 ONLY DONE 9816MILES FREE UK MAINLAND DELIVERY

Item Details

Make / Model:	FORD TRANSIT COURIER	Year:	2020
Trim:	BASE TDCI	Colour:	White
Stock Number:	00003914	Tag Number:	0000016801
Engine size:	1499	Fuel type:	Diesel
Engine Code:	XWCB	Gearbox:	6 Speed Manual

Part also fits

MONDEO 2014 - 2016 Mk5 1.6 TDCi Diesel 29/9/14-
FOCUS 2005 - 2011 1.6 TDCi Diesel
FUSION 2001 - 2012 Mk1 1.6TDCi Diesel
TRANSIT COURIER 2014 - 2020 Mk1 1.5 Di Diesel
TRANSIT COURIER 2014 - 2020 Mk1 1.6 Di Diesel 95bhp

Carlisle Car Parts

General Information

Please message us via eBay during normal working hours with your requirements.

We accept Credit/Debit cards, PayPal and bank transfer over the phone.

All parts will be shipped within 48 hours of receiving payment, via a 48 hour tracked courier.

Parts will be quoted inclusive of Delivery to a UK Mainland Postcode and will be inclusive of VAT under the global VAT scheme.

We operate under the global accounting scheme. VAT must not be reclaimed on any invoice amounts.

Warranty

We offer a 30 day warranty on all of our engines and gearboxes, unless stated otherwise at time of ordering. (Please see detailed engine and gearbox terms and conditions below).

All other parts are supplied with a 30 day warranty.

All parts are tested prior to sale. (See terms and conditions below)

Return Policy

We accept any valid return within 14 days from receipt of delivery. All refunds will be reimbursed by the original method of payment. The buyer is responsible for return delivery charges.

If you have any queries or complaints regarding delivery, PLEASE contact us via the eBay messaging system. PLEASE let us try to resolve your issue before you resort to opening a case on eBay. Once a case has been opened by the buyer, we are penalised, even if we resolve the matter to your complete satisfaction.

Delivery Policy

Delivery prices or Free Delivery offers are based upon shipment to a UK mainland postcode only, including Scotland and Wales. Customers from the Isles, Isle of Man, Channel Islands and Northern Ireland must contact us prior to purchase. European deliveries are also available subject to our discretion. Please contact us prior to purchase.

We endeavour to ship all items within 24 hours of receiving payment, in many cases much sooner.

Please bear in mind that in most cases, parts have to be removed from donor vehicles and possibly have to be cleaned and tested prior to shipment. This can obviously add to the delivery time.

All items are shipped with a courier of our choice and this may be stated in the listing. Items will be sent via a tracked, signed for, 48 hour service, unless stated otherwise. Very small items will be sent via Royal Mail 2nd Class.

If you have any queries or complaints regarding delivery, PLEASE contact us via the eBay messaging system. PLEASE let us try to resolve your issue before you resort to opening a case on eBay. Once a case has been opened by the buyer, we are penalised, even if we resolve the matter to your complete satisfaction.

Terms and Conditions

Where engines or other components are sold on an exchange basis, a surcharge will be applied at point of sale. This will be refunded upon the return of the old unit. You will need to return your old component to us, or advise us that it is available for collection, at your cost, within 14 days. Your old component needs to be complete and drained of fluids .The above only applies to units sold on an exchange basis.

We offer a 30-day minimum guarantee with all our recycled tested parts (excluding engines and gearboxes). If in this time the component proves to be faulty, we will, upon being notified within a reasonable time period, supply a replacement, if available or supply components to correct the fault or offer a refund. The guarantee applies to the component only and does not cover any labour or ancillaries. The item you have purchased has been recycled and therefore is not brand new. However, it should be of fully serviceable quality. Any defects that we are aware of will be clearly stated in the listing. We will not supply items with known defects. If you have any queries or complaints regarding an item, PLEASE contact us via the eBay messaging system. PLEASE let us try to resolve your issue before you resort to opening a case on eBay. Once a case has been opened by the buyer, we are penalised, even if we resolve the matter to your complete satisfaction.

The purchaser is responsible for ensuring that the component supplied is correct for its application prior to fitting. Parts correctly supplied by Carlisle Car Parts that are returned may be subject to a surcharge or handling charge of 20%. Any part that has been specially ordered but is no longer required by the purchaser cannot be refunded.

Trade Descriptions Act 1968-Any vehicle mileage quoted is correct to the best of our knowledge BUT has not been verified. The accuracy of the odometer reading cannot be relied upon and should be disregarded.

All body panels are supplied from used vehicles. As such, they may be perfect or they may have minor imperfections, scratches, dents or paint defects. We will highlight any known issues on the listing. We will endeavour to highlight the correct vehicle paint code in the listing but cannot be held responsible for accurate matching of manufacturer's shades.

We do not offer warranty on any external parts or labour, broken sensors or shipping costs. Any part tampered with or taken apart will invalidate warranty. Seals, gaskets, timing belts and chains are not covered by warranty. Any ancillary items may be left on for convenience and not covered by warranty - you must swap anciallary items over. ECU's & electrical items are non refundableas a result of potential damage caused by incorrect fitting or other faults in customer vehicles.

Warranty on engines only covers engine block and cylinder head. It is the purchaser's responsibility to ensure that the correct details are given to our sales team when ordering a component.

We cannot be held responsible for any part that has been taken apart or modified by another garage or individual. The warranty will then become void.

We reserve the right to have our technical team inspect or test a returned item fully, prior to credit or replacement.

PLEASE NOTE : We strongly recommend that all safety critical parts are fitted only by trained automotive technicians. No liability can be accepted for malfuction, damage or injury caused by inappropriate fitting of such componentsAll guarantees or warranties apply from the date of original purchase.

PLEASE READ BEFORE SIGNING FOR YOUR PACKAGE

Pease inspect all deliveries before signing for them. We are not able to offer credits for items that arrive damaged which may have not been signed for with the carried as "DAMAGED", even if the box looks unmarked as the consignment could have been dropped or shaken in transit. By giving a clear signature, you are accepting the goods as arriving complete and in good condition

Peugeot Citroen ford Mazda Volvo

PSA 1.6 Hdi Turbocharger Failure & Fitting Warning

ATTENTION: PLEASE READ THIS BEFORE FITTING THESE TURBOS TO YOUR CUSTOMERS VEHICLES

753420-5005S & 49173-07506 110 & 90 bhp PSA 1.6HDi TURBOS, 2004- ONWARDS The PSA 1.6HDi, DV6TED4 engine is a highly sophisticated low emission, high power diesel unit. It is used in many different applications Citroen, Ford, Mazda, Mini, Peugeot and Volvo. Due to the engine being clean and powerful, it is designed to operate with high temperatures, which demands the very best lubricants. These lubricants must be maintained in peak condition and PSA have fitted an in-line oil filter to the turbo and an integral oil cooler/oil filter to this engine to ensure this. However there is a drawback to this, reports from in the field indicate that if the engine has been operated with the oil level below normal limits, this may potentially cause a high concentration of carbon in the oil. This may then lead to blockage of the in-line filter, oil cooler and main oil filter, which will eventually bring on premature turbo failure. The vacuum pump may also suffer from this same type of contamination. However, due to its high operating speeds (230,000 revs per minute) the turbo will usually be the first to show signs of damage. This can happen from 30,000 miles onwards if the oil level and correct oil change intervals/procedure have not been adhered to. We have found that the carbon build up in this application is particularly difficult to remove. To try to eliminate the potential for further turbo failure the following must be undertaken by the garage, in addition to the normal recommended turbo fitting instructions:

TURBO OIL FEED PIPE & BANJO BOLTS MUST BE RE-PLACED WITH NEW
OIL PUMP SHOULD BE RE-PLACED WITH NEW
SUMP MUST BE REMOVED AND OIL STRAINER (PICK UP) SHOULD BE CLEANED/REPLACED BEFORE RE-FITTING NEW TURBO TO REMOVE RESIDUAL CARBON/SLUDGE BUILD UP.
OIL COOLER AND FILTER ASSEMBLY SHOULD BE REMOVED AND CLEANED.
REMOVE CHARGE AIR COOLER, DRAIN OFF ANY OIL INSIDE AND CLEAN THOROUGHLY.
CHECK AND CLEAN ALL INLET AND OUTLET HOSES.
IF OIL HAS LEAKED FROM PREVIOUSLY DAMAGED TURBO OR ENGINE INTO EXHAUST, CHECK EXHAUST SYSTEM FOR CONTAMINATION/BLOCKAGE (CATALYST, DPF etc.)
REMOVE BRAKE VACUUM PUMP TO CHECK FOR DEBRIS/CARBON AND CLEAN AS NECESSARY.
FIT TURBO LEAVING ACTUATOR PIPE OFF
FLUSH ENGINE WITH ENGINE FLUSH FOR 20 MINS THEN FIT NEW OIL FILTER AND OIL.
CHECK FUEL INJECTOR GASKETS ARE NOT BURNT OR COMPROMISED. REPLACE AS NECESSARY
OIL FLOW MUST BE CHECKED:
TAKE OIL RETURN PIPE OFF
INSTALL A LONGER OIL RETURN LINE AND FEED INTO SUITABLE CONTAINER
START ENGINE AND IDLE FOR 60 SECONDS, THEN SWITCH OFF ENGINE
MEASURE VOLUME OF OIL IN CONTAINER
60 SECONDS OF IDLE SHOULD PRODUCE AT LEAST 0.3 LITRES OF OIL.
REPEAT TEST TWO OR THREE TIMES TO CONFIRM OIL FLOW IS CORRECT
DURING THIS TEST, DO NOT ALLOW ENGINE TO RUN BELOW MINIMUM OIL LEVEL!!
VEHICLE SHOULD BE DRIVEN 20 to 30 MILES THEN THE OIL/FILTER REPLACED AGAIN.

Even after all the above has been carried out we cannot guarantee all carbon/sludge will be removed and you could still suffer a premature turbo failure. We feel that due to the possibility of further turbo failures on this engine it is only right to inform you before you purchase a replacement turbo for your customer. Currently we are experiencing a 10% failure rate of units we supply for this engine. Please feel free to speak to our engineers or sales team if you would like to discuss this issue further. Any turbo returned under warranty will be subject to our standard terms and conditions. We would also like to assure you that this is the only engine we have experienced these failure rates with. We as a company will always inform you of any ongoing issues to allow you to make the right judgement call for what you deem correct for your business.

General Information

Please message us via eBay during normal working hours with your requirements.

We accept Credit/Debit cards, PayPal and bank transfer over the phone.

All parts will be shipped within 48 hours of receiving payment, via a 48 hour tracked courier.

Parts will be quoted inclusive of Delivery to a UK Mainland Postcode and will be inclusive of VAT under the global VAT scheme.

We operate under the global accounting scheme. VAT must not be reclaimed on any invoice amounts.

Warranty

We offer a 30 day warranty on all of our engines and gearboxes, unless stated otherwise at time of ordering. (Please see detailed engine and gearbox terms and conditions below).

All other parts are supplied with a 30 day warranty.

All parts are tested prior to sale. (See terms and conditions below)

Return Policy

We accept any valid return within 14 days from receipt of delivery. All refunds will be reimbursed by the original method of payment. The buyer is responsible for return delivery charges.

If you have any queries or complaints regarding delivery, PLEASE contact us via the eBay messaging system. PLEASE let us try to resolve your issue before you resort to opening a case on eBay. Once a case has been opened by the buyer, we are penalised, even if we resolve the matter to your complete satisfaction.

Delivery Policy

Delivery prices or Free Delivery offers are based upon shipment to a UK mainland postcode only, including Scotland and Wales. Customers from the Isles, Isle of Man, Channel Islands and Northern Ireland must contact us prior to purchase. European deliveries are also available subject to our discretion. Please contact us prior to purchase.

We endeavour to ship all items within 24 hours of receiving payment, in many cases much sooner.

Please bear in mind that in most cases, parts have to be removed from donor vehicles and possibly have to be cleaned and tested prior to shipment. This can obviously add to the delivery time.

All items are shipped with a courier of our choice and this may be stated in the listing. Items will be sent via a tracked, signed for, 48 hour service, unless stated otherwise. Very small items will be sent via Royal Mail 2nd Class.

If you have any queries or complaints regarding delivery, PLEASE contact us via the eBay messaging system. PLEASE let us try to resolve your issue before you resort to opening a case on eBay. Once a case has been opened by the buyer, we are penalised, even if we resolve the matter to your complete satisfaction.

Terms and Conditions

Where engines or other components are sold on an exchange basis, a surcharge will be applied at point of sale. This will be refunded upon the return of the old unit. You will need to return your old component to us, or advise us that it is available for collection, at your cost, within 14 days. Your old component needs to be complete and drained of fluids .The above only applies to units sold on an exchange basis.

We offer a 30-day minimum guarantee with all our recycled tested parts (excluding engines and gearboxes). If in this time the component proves to be faulty, we will, upon being notified within a reasonable time period, supply a replacement, if available or supply components to correct the fault or offer a refund. The guarantee applies to the component only and does not cover any labour or ancillaries. The item you have purchased has been recycled and therefore is not brand new. However, it should be of fully serviceable quality. Any defects that we are aware of will be clearly stated in the listing. We will not supply items with known defects. If you have any queries or complaints regarding an item, PLEASE contact us via the eBay messaging system. PLEASE let us try to resolve your issue before you resort to opening a case on eBay. Once a case has been opened by the buyer, we are penalised, even if we resolve the matter to your complete satisfaction.

The purchaser is responsible for ensuring that the component supplied is correct for its application prior to fitting. Customers returning parts correctly supplied by A-Z Vehicle Dismantlers will be liable for covering delivery costs there and back, this will be a minimum of £9.50+VAT for smaller parcels and £50+VAT for palleted items. Any part that has been specially ordered but is no longer required by the purchaser cannot be refunded.

Trade Descriptions Act 1968-Any vehicle mileage quoted is correct to the best of our knowledge BUT has not been verified. The accuracy of the odometer reading cannot be relied upon and should be disregarded.

All body panels are supplied from used vehicles. As such, they may be perfect or they may have minor imperfections, scratches, dents or paint defects. We will highlight any known issues on the listing. We will endeavour to highlight the correct vehicle paint code in the listing but cannot be held responsible for accurate matching of manufacturer's shades.

We do not offer warranty on any external parts or labour, broken sensors or shipping costs. Any part tampered with or taken apart will invalidate warranty. Seals, gaskets, timing belts and chains are not covered by warranty. Any ancillary items may be left on for convenience and not covered by warranty - you must swap ancillary items over. ECU's & electrical items are non refundable as a result of potential damage caused by incorrect fitting or other faults in customer vehicles.

Warranty on engines only covers engine block and cylinder head. It is the purchaser's responsibility to ensure that the correct details are given to our sales team when ordering a component.

We cannot be held responsible for any part that has been taken apart or modified by another garage or individual. The warranty will then become void.

We reserve the right to have our technical team inspect or test a returned item fully, prior to credit or replacement.

PLEASE NOTE : We strongly recommend that all safety critical parts are fitted only by trained automotive technicians. No liability can be accepted for malfunction, damage or injury caused by inappropriate fitting of such components All guarantees or warranties apply from the date of original purchase.

PLEASE READ BEFORE SIGNING FOR YOUR PACKAGE

Please inspect all deliveries before signing for them. We are not able to offer credits for items that arrive damaged which may have not been signed for with the carried as "DAMAGED", even if the box looks unmarked as the consignment could have been dropped or shaken in transit. By giving a clear signature, you are accepting the goods as arriving complete and in good condition.

Have a Question? Get in touch!

Follow azcarparts!

Fast and Safe Delivery

Satisfaction Guaranteed

UK Based Seller

Experienced & Helpful Staff

WELCOME TO A-Z VEHICLE DISMANTLERS

FORD TRANSIT COURIER Exhaust Manifold Mk1 1.5 Diesel 14-20 ONLY DONE 9816MILES

Free Delivery

Fantastic Feedback

Based in the North West!

About Us