|
|
|
|
|
|
|
|
|
|
|
Note：
This compressor comes pre-filled with the correct amount of oil. Thus, there is no need to add any additional oil to your system.
Please add refrigerant to 70-80% without filling up.
There may be noise if the refrigerant is added too much.
Description：
Interchange Part Number:CO 4574JC
Direct Replacement
Application:
2006-2014 VOLKSWAGEN BEETLE
2010 VOLKSWAGEN BEETLE CABRIO
2010-2014 VOLKSWAGEN GOLF
2005-2014 VOLKSWAGEN JETTA
2012-2014 VOLKSWAGEN PASSAT
2008 VOLKSWAGEN R32
2006-2009 VOLKSWAGEN RABBIT
Installation Method
Attention Please:
Be sure to clean the air conditioning system before installation, otherwise it will cause compression broken.
1. Remove compressor:
Remove the A/C belt from the A/C compressor pulley. May involve loosening the belt tensioner (if equipped).
2.receiver drier or accumulator, orifice tube or expansion valve.
3.Disconnect the negative battery cable.
4.Remove the bolt that secures refrigerant lines to the A/C compressor. Inspect A/C lines for any contamination such as metal or excessive dirt inside of them. If you find any
contamination the system will need to be cleaned.Flush the condenser and evaporator using NON-OIL BASED A/C flush. On expansion valve systems. The valve must be removed before
the evaporator can be flushed. Flushed condensers from outlet to inlet and evaporators from inlet to outlet.
5.Drain all the oil from the new compressor ,if you compressor has a drain plug you will need to open it up and drain what oil is in there too.
6.Install half oil charge into the compressor and the remainder throughout the system. Turn compressor shaft 8-10 full revolutions to insure front seal and other internal
parts are lubricated.
7.Install new receiver drier or accumulator and new orifice tube or expansion valve.
8.Evacuate the A/C system for a minimum of one hour.
9.After evacuation install half the refrigerant charge and let the system set for 1 minute. This will allow the refrigerant to pick up oil and spread more evenly throughout
the system.
10.Turn on the A/C system with the engine running and check to see if cold air is now coming out of the air duct.
11.If the A/C system is functioning ,you may find that your electric radiator fan and compressor clutch will be cycling off and on depending on the outside air temperature.
To confirm that this part fits your vehicle, enter your vehicle's Year, Make, Model, Trim and Engine in the Compatibility Table.
| Item Specifics | |
|---|---|
| Manufacturer Warranty | 1 Year |
| Interchange Part Number | CO 4574JC |
| Manufacturer Part Number | AS288553MM |
| Brand | auto-summer |
| Placement on Vehicle | Front |
| Surface Finish | Polished |
| Fitment Type | Direct Replacement |
| Type | Compressor & Clutch Assembly |
we accept payment through PayPal only. Payments must be received within 14 days of auction end.
We process your order within 3 business day upon payment
Please contact us first when return, exchange and refund is required.
Any direct return of purchased items will not be processed.
Buyer is responsible for the return cost.
Change-of-mind return can only be accepted within 7 days after purchase.
All other returns can be accepted in 30 days.
We specialize in air conditioning compressor and clutch service,Customer satisfaction is our first priority. If you have this requirement,Please contact us !
Shop Category Hot Item
Help & Info Payment Policy Shipping Policy Return Policy FAQ About Us New List Item
|
AC Compressor For 2006-2014 VW Beetle Base Golf Jetta Audi TT RS Quattro 2.5L
Note： This compressor comes pre-filled with the correct amount of oil. Thus, there is no need to add any additional oil to your system. Please add refrigerant to 70-80% without filling up. There may be noise if the refrigerant is added too much.
Description： Direct Replacement
Application: 2006-2014 VOLKSWAGEN BEETLE 2010 VOLKSWAGEN BEETLE CABRIO 2010-2014 VOLKSWAGEN GOLF 2005-2014 VOLKSWAGEN JETTA 2012-2014 VOLKSWAGEN PASSAT 2008 VOLKSWAGEN R32 2006-2009 VOLKSWAGEN RABBIT
Installation Method
Attention Please: Be sure to clean the air conditioning system before installation, otherwise it will cause compression broken. 1. Remove compressor: Remove the A/C belt from the A/C compressor pulley. May involve loosening the belt tensioner (if equipped). 2.receiver drier or accumulator, orifice tube or expansion valve. 3.Disconnect the negative battery cable. 4.Remove the bolt that secures refrigerant lines to the A/C compressor. Inspect A/C lines for any contamination such as metal or excessive dirt inside of them. If you find any contamination the system will need to be cleaned.Flush the condenser and evaporator using NON-OIL BASED A/C flush. On expansion valve systems. The valve must be removed before the evaporator can be flushed. Flushed condensers from outlet to inlet and evaporators from inlet to outlet. 5.Drain all the oil from the new compressor ,if you compressor has a drain plug you will need to open it up and drain what oil is in there too. 6.Install half oil charge into the compressor and the remainder throughout the system. Turn compressor shaft 8-10 full revolutions to insure front seal and other internal parts are lubricated. 7.Install new receiver drier or accumulator and new orifice tube or expansion valve. 8.Evacuate the A/C system for a minimum of one hour. 9.After evacuation install half the refrigerant charge and let the system set for 1 minute. This will allow the refrigerant to pick up oil and spread more evenly throughout the system. 10.Turn on the A/C system with the engine running and check to see if cold air is now coming out of the air duct. 11.If the A/C system is functioning ,you may find that your electric radiator fan and compressor clutch will be cycling off and on depending on the outside air temperature. To confirm that this part fits your vehicle, enter your vehicle's Year, Make, Model, Trim and Engine in the Compatibility Table. Payment
we accept payment through PayPal only. Payments must be received within 14 days of auction end. We process your order within 3 business day upon payment Shipping
We process and dispatch your purchase within 3 business day after payment clearance.
Please contact us if you have special requirements (combination of packaging etc.).
We offer free USPS or FEDEX Package as default.
If you choose express post, we charge a flat rate and we Express Post, which can be delivered in 1-3 business days, depending
on your location. If you require another company, please contact us.
Returns
Please contact us first when return, exchange and refund is required. Any direct return of purchased items will not be processed.Buyer is responsible for the return cost.Change-of-mind return can only be accepted within 7 days after purchase.All other returns can be accepted in 30 days.Contact Us
Before leaving us neutral or negative feedback, please contact us first.
We will do everything we can to give you a satisfying solution.
Please don't open case via eBay or PayPal.
Please don't open any return request before contact us.
We do our best to resolve any issue. Leaving negative feedback and low ratings doesn't get things solved.
So please talk with us and we will not let you down.
About Us
We specialize in air conditioning compressor and clutch service,Customer satisfaction is our first priority. If you have this requirement,Please contact us ! All rights reserved. |
