Bond It Solar Reflective Aluminium Roof Repair Bitumen Based Paint 25L

 Description:
A thin, bituminous based aluminium protective coating of brushing consistency that dries to a silvery finish.

Uses
Bond It ALUMINIUM SOLAR REFLECTIVE PAINT is a light/heat
reflective coating that will provide protection against solar
degradation and heat gain. It is suitable for use over bituminous
coatings, aged asphalt and primed steel. It is not suitable for direct
application to expanded polystyrene.

Preparation
All surfaces must be structurally sound, clean, dry and free from
surface contaminants such as grease, rust
and dirt. If necessary, remove any organic
growth i.e. lichen, with a fungicidal wash
such as Bond It MOULD STOP. If
the surface is still dusty after
cleaning, or covered with
weathered bitumen, prime
with BITUMEN PRIMER and
allow to dry.

Application
STIR VERY THOROUGHLY BEFORE USE. Do not thin. Apply
immediately and continue stirring periodically during use. Apply
by brush or mohair roller When brushing, use soft bristle brushes
applying the lightest of pressure. The product will appear bronze
coloured in the tin, but will turn silver as it dries.
Over recently applied bituminous surfaces allow the following
minimum periods to elapse after the final coat has dried before
applying ALUMINIUM SOLAR REFLECTIVE PAINT:-
hot applied coatings ‐ 24 hours.
solvent based coatings ‐ 10 days.
water based coatings ‐ 14 days.
Apply 2 coats, the second coat being applied as soon as the first coat is
dry.
Over bituminous surfaces apply the thinnest coat necessary to
obliterate the black colour of the bitumen coating for the first
coat. The second coat should also be thin. Avoid the formation of
pools.
Do not apply when rain, frost or overnight dew are expected
before the coating is fully dry, as bronzing of the surface may
result if these conditions are not observed.

When applying to large areas on bright days it is advisable to wear
polarized sunglasses to reduce glare.

Drying Time
Approximately 1 hour depending on temperature, humidity, air
and base conditions.

Cleaning Of Tools
Clean with paraffin (kerosene) or Bond It WHITE SPIRIT.

Colour
Silver in colour.

Container Size
Available in 25L metal tins.

Storage Life
Minimum of 5 years from date of manufacture under good storage
conditions in original unopened containers.

Storage Conditions
Store under cover away from sources of heat and ignition. Keep
containers sealed when not in use. Storage temperature should be
between 5o
C and 30oC.

Disposal of Containers
Do not leave containers on site where residue could be a hazard to
children, animals or the environment. Replace lids securely and
remove any containers to a central disposal point.

Health & Safety
Please refer to separate material safety data sheet for full
handling, use and storage instructions. Keep out of reach of
children. It is the users responsibility to determine suitability for
use. If in doubt contact our Technical Department for advice.
Note: this information is for general guidance only, since site conditions
and labour are beyond our control. It is recommended that users make
their own tests to determine suitability.

Specification Summary
Type of Solvent Petroleum Hydrocarbons
Approximate Flashpoint Test Method BS2000:Part 170:1982 [IP170/75 (81)] 40oC
Approximate Specific Gravity 1.0
Approximate Coverage 4 - 6m2 per litre
(dependant on substrate porosity)
Service Temperature Limits -30o
C to +90o
C depending on
operating conditions
Application Temperature Limits Normally 5o
C to 30oC
Chemical Resistance Resistant to: water and most salt solutions
Not Resistant to: acids, alkalis and solvents
Fire Resistance WET: Flammable
DRY: Will burn slowly
UN Number 1263
UFI 2G50-Q0UW-F00M-DX3P

Product Details:
Size:  25 Litres
Colour:  Silver
Code:  BDB022
Barcode:  5060021362384

Package Content:
Bond It Solar Reflective Aluminium Roof Repair Bitumen Based Paint 25 LTR