OUT OF STOCK !!!
Yamaha YZF-R1 2015+ Race Generator kit
This is the complete race generator kit including the lightweight flywheel, stator, mounting plate, cup fasteners, BDK Kit casing, connectors and specific regulator / rectifier,Instructions and stickers.
Installation of this generator is very simple just remove your original rotor and replace with ours. Then remove the OEM cover from your bike and fit ours, thread the stator wires through your grommet.Slide the protective sheath over and fit the connector, connect 3 wires and you are finished.It’s the easiest hp gain you will ever have!
OUT OF STOCK !!!
This Generator that is Significantly lighter than standard, offering higher output than 'race kit' versions, providing increased throttle response,less gyroscopic forces and more bhp everywhere. It is designed to fit high performance Race engines, and as a replacement for standard alternator systems.
Typical gains on a standard bike are around 4-5bhp and generally the higher the state of tune of the bike the greater the gain.Please see the photo of the graph, this was taken before and after a Kawasaki ZX10 generator install on a customers bike.
OUT OF STOCK !!!
Most race kit generators have a smaller rotor with less windings running single phase in the stator so that they produce less outright power (and accordingly take less power from the crank to generate the electricity), and use a standard reg/rec.
The problem with this is that you have to rev the engine quite hard to produce any useable power and any excess electricity created is still converted to heat in the reg/rec and thrown out the back of the bike.
OUT OF STOCK !!!
Our generators also use a small rotor but our windings are 3 phase and have a lot of turns of fine wire. This allows us to provide strong and consistent power at lower revs, but the clever part is in the reg/rec. The reg/rec contains a switching system which cuts the generating power when the desired voltage is reached and therefore the power is not taken from the crank to convert to unwanted electricity in the first place. This is why our reg/recs run much cooler than standard models and why you cannot use our generators with a standard reg/rec as the generator would be under load all the time creating excessive heat in the windings.
Intended Use | Racing |
Machine Type | Dual Sport Motorcycle |
Machine Type | Street Motorcycle |
Brand | BDK |
Unit Quantity | 1 |
Manufacturer Part Number | Does Not Apply |